噴漆涂裝線在施工中使用的是非常好的，他一般采用靜電噴涂方式對工件進行噴涂，噴房的主要設備由噴粉室、靜電噴粉設備及噴槍、粉末回收裝置等組成。這種水簾噴漆室簡單實用，目前在噴漆涂裝線中應用較多。
The spray painting line is very good in construction. It generally uses electrostatic spraying to spray the workpiece. The main equipment of the spray room is composed of powder spraying room, electrostatic powder spraying equipment, spray gun and powder recovery device. This kind of water curtain spray booth is simple and practical, and it is widely used in painting line.
水簾噴漆室前面為水簾板，水簾板上面有溢流槽，在施工的過程中，工件由懸掛輸送鏈送入噴漆室。操作者用手持式靜電噴漆槍或固定式旋杯噴漆槍對工件進行噴涂作業時，飛散的過噴漆霧隨氣流吸引，進入噴漆室，與水簾板的水幕相遇，被沖刷到水槽內，其余漆霧在通過多級水簾噴淋凈化后，完全被攔截在水中。
In front of the water curtain spray room is a water curtain board, and there is an overflow groove on the water curtain board. During the construction process, the workpiece is sent to the spray paint room by the suspension conveyor chain. When the operator uses a hand-held electrostatic spray gun or a fixed rotary cup spray gun to spray the workpiece, the scattered overspray mist is attracted by the air flow and enters the spray booth. First, it meets the water curtain of the water curtain board and is washed into the water tank. The rest of the paint mist is completely intercepted in the water after being cleaned by multi-stage water curtain.
去漆霧后的氣流再經氣水分離裝置，去除氣味處理，凈化后的氣體比較后對外排放。水簾捕捉到的漆霧隨水流瀉入盛水池，經水泵抽吸過濾，油漆殘渣浮于水面，在加入水池內的油漆凝聚劑作用下，凝聚成疏松團塊，可用盛器舀出集中處理，保持水質清潔。通過水簾噴漆室及輔助設備的作用，可較理想地完成對工件噴漆及漆霧凈化目的。
After the paint mist is removed, the air flow will pass through the gas water separation device to remove the odor, and the purified gas is finally discharged to the outside world. The paint mist captured by the water curtain flows into the water tank with the water flow, and the paint residue floats on the water surface after being pumped and filtered by the water pump. Under the action of adding the paint coagulant in the pool, it can be agglomerated into loose lumps, which can be scooped out by the container for centralized treatment to keep the water quality clean. Through the function of water curtain spray booth and auxiliary equipment, the purpose of painting work piece and paint mist purification can be completed ideally.
在電氣防爆(火)方面，也存在較多的欠缺，如：電氣防爆(火)等級不符合強制性標準要求、防爆(火)設施配置不完全等問題。由于這些問題一般不對工件噴涂質量造成影響，因此往往不被重視或從成本考慮而被削減，因此更需有關部門的監督及強制要求加以促進，以消除安全隱患，改善操作人員的工作環境，并使廢氣(水)達標排放，環保型涂料得到迅速發展，對減少環境污染起到了積極的作用。
In terms of electrical explosion-proof (fire), there are also many deficiencies, such as: the electrical explosion-proof (fire) level does not meet the requirements of national mandatory standards, explosion-proof (fire) facilities configuration is not complete and so on. As these problems generally do not affect the quality of workpiece spraying, they are often ignored or reduced from the cost consideration. Therefore, it is necessary to promote the supervision and mandatory requirements of relevant departments to eliminate potential safety hazards, improve the working environment of operators, and make exhaust gas (water) discharge up to standard. Environmental protection coatings have been developed rapidly, which has played a positive role in reducing environmental pollution The role of.